Spiking in voltage with Rotax 582 Blue top.
Posted: Thu Jul 17, 2014 7:55 am
Hi fellow aviators,
During my last flight, at cruising RPM, I noticed a sudden spike in voltage (13.5 to 16vdc), normally constant at 13.5 vdc. This spiking returned to normal (13.5 vdc) within +- a minute. I landed, and did a ground run check at various rpm settings. A few spikes to 16 vdc, lasting for +_ a minute each re- occurred. (This fault is intermittent) The engine was shut down, and all electrical connections concerning the charging circuit were checked. No obvious faults were found. I suspect a possible voltage regulator fault. Is there a way to check the regulator before just replacing the unit? Any other suggestions? I am afraid of damaging the radio and instrument panel, and want to sort this out asap.
Regards,
Andries
During my last flight, at cruising RPM, I noticed a sudden spike in voltage (13.5 to 16vdc), normally constant at 13.5 vdc. This spiking returned to normal (13.5 vdc) within +- a minute. I landed, and did a ground run check at various rpm settings. A few spikes to 16 vdc, lasting for +_ a minute each re- occurred. (This fault is intermittent) The engine was shut down, and all electrical connections concerning the charging circuit were checked. No obvious faults were found. I suspect a possible voltage regulator fault. Is there a way to check the regulator before just replacing the unit? Any other suggestions? I am afraid of damaging the radio and instrument panel, and want to sort this out asap.
Regards,
Andries